Ka24de sputtering issue

[Bmx240sx]

Car randomly started to sputter at high rpms maybe like 4K ish my maf is good and I just got a new o2 sensor I don't know what else could be the problem plugs are about a month old and everything else is new such as ignition coil, dizzy, fuel filter, fuel pump etc. some one help I wanna go sliding :((


Sent from my iPhone using Tapatalk

[boatwright_doug]

Check your fuel pump

Sent from my SM-G930V using Tapatalk

[Bmx240sx]

Check your fuel pump

Sent from my SM-G930V using Tapatalk



What should I check on it ? It's new idk what could Go bad on it in such a short amount of time?


Sent from my iPhone using Tapatalk

[boatwright_doug]

I'm not a master tech but from experience to check my spark, fuel and air, you could have a simple vacuum line pinched or split for all you know. A good start would be to check all the stuff you replaced recently

Sent from my SM-G930V using Tapatalk

[Bmx240sx]

Yea everything looks to be normal


Sent from my iPhone using Tapatalk

[Bmx240sx]

So I did a little of ecu work today and got it to read code 55 which is (settings OK) and my car is still sputtering. It's not at a certain rpm now it's just sputtering at random I'm thinking it has something to do with fuel? Maybe injectors? Any inputs?


Sent from my iPhone using Tapatalk

[Jefro240]

I'm thinking it has something to do with fuel? Maybe injectors? Any inputs?

While the car is running try unplugging injectors 1 @ a time... If you unplug 1 and the sputter/idle doesn't change then you could have a dead injector. If it gets worse, that injector is working fine.

[Bmx240sx]

While the car is running try unplugging injectors 1 @ a time... If you unplug 1 and the sputter/idle doesn't change then you could have a dead injector. If it gets worse, that injector is working fine.



The idle of the car is fine it's only sputtering when I try to floor it, if I try to ease into it also it's fine just when I try to floor it the car starts to act like I have some sort of anti lag on it and my buddies even said it shot a flame when it was sputtering


Sent from my iPhone using Tapatalk

[Bmx240sx]

I've had this similar problem with the previous motor ( sohc ) and all I did was clean out gunk from top of injectors and it revved all the way up no break ups


Sent from my iPhone using Tapatalk

[Bmx240sx]

Also no codes are being thrown


Sent from my iPhone using Tapatalk

[Bmx240sx]

Update: checked the fuel pump and tank and found a lot of sandish material inside


Sent from my iPhone using Tapatalk

[Bmx240sx]

https://uploads.tapatalk-cdn.com/20170207/46e42e97a5309078e32e6ef5dc02f08b.jpg


Sent from my iPhone using Tapatalk

[Bmx240sx]

Tried emptying out as much as I can and the car is kinda acting the same


Sent from my iPhone using Tapatalk

[Bmx240sx]

B


Sent from my iPhone using Tapatalk

[Bmx240sx]

[emoji33]


Sent from my iPhone using Tapatalk

[boatwright_doug]

Flush the tank, check fuel pump voltage to see if it's any good, check your fuel filter, if the filter did its job then you're gonna need to flush the fuel line and replace the filter again

Sent from my SM-G930V using Tapatalk

[TheNigguh_Danny]

Bro is your problem still going on I recommend changing all your fuel components check your fuel filter in the engine bay & see if it's filled with that


Sent from my iPhone using Tapatalk

[Bmx240sx]

Bro is your problem still going on I recommend changing all your fuel components check your fuel filter in the engine bay & see if it's filled with that


Sent from my iPhone using Tapatalk



Yea I fixed the issue my injectors were never messed up, turns out the sand substance in my fuel tank was old gas so I took out the fuel tank and scraped off all the sand stuff from the walls and off the baffle then I hosed it down and scrubbed it all down to make sure I got most of it out and finally 4 fuel filters later the car is running fine [emoji1360]


Sent from my iPhone using Tapatalk

[EnnEssEnnKAT]

That's great news and impressive fortitude on your part.

Sent from mTalk

[TheNigguh_Danny]

Nice good to hear


Sent from my iPhone using Tapatalk